AP-1000D, AP-1055D, AP-655C, BG-2255C, BG-2455D and BG-260D Asphalt Pavers MID 039 - CID 0168 - FMI 03 Caterpillar


MID 039 - CID 0168 - FMI 03
`

Conditions Which Generate This Code:

This diagnostic code is recorded when the ECM reads the system voltage as being greater than 32 DCV.

The possible causes of this diagnostic code are listed:

  • A charging system component has failed.

  • The wiring of the machine harness has failed.

  • The ECM has failed. This is unlikely.

System Response:

When this diagnostic code occurs, the action lamp and the action alarm is ON. The lamp for system voltage is also ON.

Test Step 1. CHECK THE CHARGING SYSTEM.

  1. Turn the disconnect switch and the key start switch to the ON position.

  1. Place CID 0168 FMI 03 on hold. .

  1. View the status of the diagnostic code.

Expected Result:

The diagnostic code is NO longer active.

Results:

  • YES - The diagnostic code is NO longer active. Proceed to test step 2.

  • NO - The diagnostic code remains active. Proceed to test step 3.

Test Step 2. CHECK THE CHARGING SYSTEM AGAIN.

  1. Start the engine.

  1. Place CID 0168 FMI 03 on hold.

  1. View the status of the diagnostic code.

Expected Result:

The diagnostic code is NO longer active.

Results:

  • YES - The diagnostic code is NO longer active. Watch for a recurrence. Stop.

  • NO - The diagnostic code is active. The charging system is charging at an excessive voltage.

    Repair: Check the charging system. See Special Instruction, REHS0354, "Charging System Troubleshooting" for more information.

    Stop.

Test Step 3. CHECK THE BATTERY VOLTAGE.

  1. The engine should not be running.

  1. At the battery, measure the voltage of the battery.

Expected Result:

The voltage should measure less than 32 DCV.

Results:

  • YES - The voltage measures less than 32 DCV. The ECM must be recording this diagnostic code incorrectly. The ECM may have failed.

    Repair: It is unlikely that the ECM has failed. Exit this procedure and perform this procedure again. If the cause of the diagnostic code is NOT found, replace the ECM. See Troubleshooting, "Electronic Control Module (ECM) - Replace".

    Stop.

  • NO - The voltage measurement is greater than 32 DCV. The charging system is charging at an excessive voltage.

    Repair: Check the charging system.

    Stop.

Information System:

574B Forwarder Power Train Hydrostatic Drive System
AP-655C and BG-2255C Asphalt Pavers Propel System Piston Pump Neutral - Test and Adjust
3524B Engine for Caterpillar Built Machines Crankshaft Rear Seal and Wear Sleeve - Remove
797 Off-Highway Truck Power Train Transmission
RM-350B Road Reclaimer/Soil Stabilizer Machine Systems Rotor Drive Differential - Assemble
R2900 Load Haul Dump Machine Operation Information
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks Air Filter Restriction Lamp
3524B Engine for Caterpillar Built Machines Engine Oil Sequence Valves - Remove and Install
CP-563E, CP-573E, CS-563E, CS-573E and CS-583E Vibratory Soil Compactors Vibratory System Features
R2900 Load Haul Dump Transmission Control
TK711, TK721, TK722 and TK732 Track Feller Bunchers Hydraulic System Piston Motor (Swing Drive) Relief Valve Pressure - Test and Adjust
AP-1000D, AP-1055D, AP-655C, BG-2255C, BG-2455D and BG-260D Asphalt Pavers MID 039 - CID 0154 - FMI 08
AP-1000D, AP-1055D, AP-655C, BG-2255C, BG-2455D and BG-260D Asphalt Pavers MID 039 - CID 0168 - FMI 04
CS-563E, CP-563E, CS-573E, CP-573E, CS-583E, CP-583E, CS-663E, CP-663E and CS-683E Vibratory Soil Compactors Drum Scrapers - Inspect/Adjust/Replace
120H and 135H Motor Graders Seat Belt
2002/11/18 Replacement Mobil-Trac System Belts Are Now Available for John Deere 8000T Series Agricultural Tractors {4198}
R2900 Load Haul Dump Stopping the Engine
CB-534D, CB-534D XW and CB-564D Paving Compactors Machine Systems Metering Pump (Steering)
14H Motor Grader Machine Systems Fuel Tank (Left Side) - Remove
14H Motor Grader Machine Systems Fuel Tank (Left Side) - Install
R2900 Load Haul Dump Lift Arm Positioner
CB-534D, CB-534D XW and CB-564D Vibratory Asphalt Compactors Vibratory System Piston Pump (Vibratory)
CB-534D, CB-534D XW and CB-564D Vibratory Asphalt Compactors Vibratory System Vibratory Valve
CB-534D, CB-534D XW and CB-564D Vibratory Asphalt Compactors Vibratory System Piston Motor (Vibratory)