CP-563C and CS-563C Vibratory Compactors Engine Air Filter Primary Element - Clean/Replace Caterpillar


Engine Air Filter Primary Element - Clean/Replace
`
CP-563C and CS-563C Vibratory Compactors [KEBU6860]
AIR INLET AND EXHAUST SYSTEM
AIR CLEANER GP
CP-563C and CS-563C Vibratory Compactors Engine Air Filter Primary Element - Clean/Replace


NOTICE

Service the air cleaner only with the engine stopped. Engine damage could result.


Service the air cleaner filter element when the yellow piston on the engine air filter service indicator enters the red zone or the indicator reads 63.5 cm (25 inch) of water. Refer to Operation and Maintenance Manual, "Engine Air Filter Service Indicator - Inspect".

  1. Open the access door on the left side of the machine.


    Illustration 1g00537958

  2. Squeeze the outlet tube slightly in order to purge the dirt from the outlet tube.


    Illustration 2g00101413

  3. Loosen the four cover latches and remove the air cleaner cover.


    Illustration 3g00101415

  4. Remove the primary filter element from the air cleaner housing.

  5. Clean the air cleaner cover and the inside of the air cleaner housing.

  6. Inspect the O-ring seal on the air cleaner cover. Replace the O-ring seal if the O-ring seal is worn or damaged.


    NOTICE

    Do not clean the filter elements by bumping or tapping them. Do not use filter elements with damaged pleats, gaskets or seals. Engine damage can result.

    Make sure the cleaned filter elements are completely dry before installing into the filter housing. Water remaining in the elements can cause false indications of contamination in Scheduled Oil Sampling test results.


  7. Clean the primary filter. Inspect the primary filter.

    Primary filter elements can be cleaned with low pressure air. AVSpare does not recommend cleaning the air filter.

    Refer to Operation and Maintenance, "General Hazard Information" before you use pressure air in order to clean the primary filter element.



    Illustration 4g00102970

  8. Direct air along the pleats inside the primary filter element and outside the primary filter element. Do not touch pleats with the air nozzle.

  9. Inspect the primary filter element after the element is clean. Do not use a primary filter element with damaged pleats, damaged gaskets or damaged seals.

  10. Encase the clean primary filter element and store the clean primary filter element in a clean, dry place.

  11. Install the clean primary filter.

  12. Install the air cleaner cover and close the latches securely.


    Illustration 5g00101416

    Note: Install the air cleaner cover properly. The arrows must point upward.

  13. Change the filter if the exhaust smoke is still black.

    Note: Replace the primary filter if the primary filter has been in service for one year.

  14. Close the access door.

Information System:

R2900 Load Haul Dump Automatic Brake Application System (Low Transmission Oil Pressure) - Test - If Equipped
793B Off-Highway Truck Suspension Cylinder Suspension Cylinder (Rear)
793B Off-Highway Truck Suspension Cylinder Suspension Cylinder (Front)
938G Series II Wheel Loader and IT38G Series II Integrated Toolcarrier Braking System Accumulator Charging Valve (Brake) - Test and Adjust
R2900 Load Haul Dump Lubricant Viscosities
CB-534D, CB-534D XW and CB-564D Vibratory Asphalt Compactors Vibratory System Eccentric Weight
CB-534D, CB-534D XW and CB-564D Vibratory Asphalt Compactors Vibratory System Piston Motor (Vibratory)
CB-534D, CB-534D XW and CB-564D Vibratory Asphalt Compactors Vibratory System Vibratory Valve
CB-534D, CB-534D XW and CB-564D Vibratory Asphalt Compactors Vibratory System Piston Pump (Vibratory)
R2900 Load Haul Dump Lift Arm Positioner
14H Motor Grader Machine Systems Fuel Tank (Left Side) - Install
14H Motor Grader Machine Systems Fuel Tank (Left Side) - Remove
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks Service Engine Lamp
14H and 16H Motor Graders Power Train Power Train
3524B Engine for Caterpillar Built Machines Water Pump - Install
14H Motor Grader Machine Systems Piston Pump (Hydraulic and Steering) - Remove
CB-434D, CB-534D, CB-534D Series XW and CB-564D Paving Compactors Power Supply Circuit of Electronic Control Module
3054E Industrial Engine Glow Plugs - Test
R2900 Load Haul Dump Belts - Inspect/Adjust
3054E Industrial Engine Engine Valve Lash - Inspect/Adjust
CS-563E, CP-563E, CS-573E, CP-573E, CS-583E, CP-583E, CS-663E, CP-663E and CS-683E Vibratory Soil Compactors Engine Oil Level - Check
CS-563E, CP-563E, CS-573E, CP-573E, CS-583E, CP-583E, CS-663E, CP-663E and CS-683E Vibratory Soil Compactors Engine Oil Sample - Obtain
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks Engine Overspeed Lamp and Engine Overspeed Alarm
CS-563E, CP-563E, CS-573E, CP-573E, CS-583E, CP-583E, CS-663E, CP-663E and CS-683E Vibratory Soil Compactors Engine Oil and Filter - Change