834B and 836 Landfill Compactor Transmission Oil - Change Caterpillar


Transmission Oil - Change
`
834B and 836 Landfill Compactor [SEBU6696]
POWER TRAIN
FILLER GP-POWER TRAIN OIL
834B and 836 Landfill Compactor Transmission Oil - Change


NOTICE

Care must be taken to ensure that fluids are contained during performance of inspection, maintenance, testing, adjusting and repair of the product. Be prepared to collect the fluid with suitable containers before opening any compartment or disassembling any component containing fluids.

Refer to Special Publication, NENG2500, "AVSpare Tools and Shop Products Guide" for tools and supplies suitable to collect and contain fluids on AVSpare products.

Dispose of all fluids according to local regulations and mandates.


  1. Operate the machine in order to warm the transmission oil.

  1. Park the machine on level ground. Lower the blade to the ground and apply slight downward pressure.

  1. Engage the parking brake. Stop the engine.



    Illustration 1g00275154



    Illustration 2g00038565

  1. Remove the transmission drain plug from the bottom of the transmission case. Allow the oil to drain into a suitable container.

  1. Change the transmission oil filter.

    Reference: Refer to Operation and Maintenance Manual, "Transmission Oil Filter - Replace" for the correct procedure.

  1. Clean the transmission magnetic screen.

    Reference: Refer to Operation and Maintenance Manual, "Transmission Magnetic Screen - Clean" for the correct procedure.

  1. Clean the transmission drain plug. Install the transmission drain plug.



    Illustration 3g00275236

  1. Open the access door on the platform behind the cab.



    Illustration 4g00038569

  1. Remove the transmission oil filler cap. Fill the transmission with oil through the filler tube.

    Reference: Refer to Operation and Maintenance Manual, "Lubricant Viscosities and Refill Capacities" for the correct type of oil and for the correct amount of oil.

  1. Clean the transmission oil filler cap. Install the transmission oil filler cap.



    Illustration 5g00669376

  1. Remove the transmission breather. Wash the breather in a clean, nonflammable solvent. Allow the breathers to dry or use air pressure to dry the breather. Install the breather.

    Note: 834B Wheel Tractors (7BR1-596 ) and 836 Landfill Compactors (7FR1-263 ) have a breather vent on the torque converter.

  1. Start and run the engine at low idle. Apply the service brake.

  1. Slowly operate the transmission controls in order to circulate the oil.

  1. Move the transmission control to the NEUTRAL position. Engage the parking brake. Stop the engine. Inspect the entire transmission system for leaks.

  1. Check the transmission oil level.

    Reference: Refer to Operation and Maintenance Manual, "Transmission Oil Level - Check" for the correct procedure.

  1. Close the access door.

Information System:

834B and 836 Landfill Compactor Hydraulic System Oil Level - Check
834B and 836 Landfill Compactor Hydraulic System Oil - Change
834B and 836 Landfill Compactor Steering Cylinder Bearings - Lubricate
834B and 836 Landfill Compactor Fuses - Replace
834B and 836 Landfill Compactor Fuel Tank Cap and Strainer - Clean
834B and 836 Landfill Compactor Fuel System Secondary Filter - Replace
834B and 836 Landfill Compactor Fuel System - Prime
834B and 836 Landfill Compactor Engine Oil (High Speed) and Oil Filter - Change - If Equipped
834B and 836 Landfill Compactor Ether Starting Aid Cylinder - Replace
834B and 836 Landfill Compactor Differential and Final Drive Oil - Change
834B and 836 Landfill Compactor Cab Air Filter - Clean/Replace
834B and 836 Landfill Compactor Coolant Conditioner Element - Replace
834B and 836 Landfill Compactor Rollover Protective Structure (ROPS) - Inspect
834B and 836 Landfill Compactor Transmission Oil Filter - Replace
CP-433C, CS-431C and CS-433C Paving Compactors Engine Starting with Jump Start Cables
834B and 836 Landfill Compactor After Starting Engine
D6R Track-Type Tractor Operation
D9R Track-Type Tractor Standard Torque for Worm Drive Band Hose Clamps
844 Wheel Dozer Tree or Brush Removal
834B and 836 Landfill Compactor Starting with Auxiliary Start Receptacle
834B and 836 Landfill Compactor Throttle Lock Control
561M Pipelayer Track Roller Frame Guides - Inspect
834B and 836 Landfill Compactor Refill Capacities
834B and 836 Landfill Compactor Caterpillar Reference Material