834B and 836 Landfill Compactor Fuel System Secondary Filter - Replace Caterpillar


Fuel System Secondary Filter - Replace
`


NOTICE

Do not fill fuel filters with fuel before installing them. Contaminated fuel will cause accelerated wear to fuel system parts.





Illustration 1g00275094

  1. Open the access cover on the left side of the machine.



    Illustration 2g00038555

  1. Remove the used filter element. Dispose of the used filter element properly.

  1. Clean the filter mounting base. Make sure that all of the used seal is removed.

  1. Lubricate the seal of a new filter with clean diesel fuel.

  1. Install the new filter by hand. After the gasket contacts the filter base, tighten the filter by an additional 3/4 turn.

    There are rotation index marks on the filter at 90 degree intervals. Use these marks as a guide for proper tightening.

  1. Prime the fuel system.

    Reference: Refer to Operation and Maintenance Manual, "Fuel System - Prime" for the correct procedure.

  1. Close the access cover.

Information System:

834B and 836 Landfill Compactor Fuel System - Prime
834B and 836 Landfill Compactor Engine Oil (High Speed) and Oil Filter - Change - If Equipped
834B and 836 Landfill Compactor Ether Starting Aid Cylinder - Replace
834B and 836 Landfill Compactor Differential and Final Drive Oil - Change
834B and 836 Landfill Compactor Cab Air Filter - Clean/Replace
834B and 836 Landfill Compactor Coolant Conditioner Element - Replace
834B and 836 Landfill Compactor Circuit Breakers - Reset
834B and 836 Landfill Compactor V-Belts - Inspect/Adjust/Replace
834B and 836 Landfill Compactor Lift Control
834B and 836 Landfill Compactor Air Conditioner - Test
834B and 836 Landfill Compactor Transmission Direction and Speed Control
834B and 836 Landfill Compactor Parking Brake Control
834B and 836 Landfill Compactor Fuel Tank Cap and Strainer - Clean
834B and 836 Landfill Compactor Fuses - Replace
834B and 836 Landfill Compactor Steering Cylinder Bearings - Lubricate
834B and 836 Landfill Compactor Hydraulic System Oil - Change
834B and 836 Landfill Compactor Hydraulic System Oil Level - Check
834B and 836 Landfill Compactor Transmission Oil - Change
834B and 836 Landfill Compactor Rollover Protective Structure (ROPS) - Inspect
834B and 836 Landfill Compactor Transmission Oil Filter - Replace
CP-433C, CS-431C and CS-433C Paving Compactors Engine Starting with Jump Start Cables
834B and 836 Landfill Compactor After Starting Engine
D6R Track-Type Tractor Operation
D9R Track-Type Tractor Standard Torque for Worm Drive Band Hose Clamps